Ce-niehoff-co C701etc/C703etc Alternator Retrofit/Upgrade Instal Manual de usuario descargar pdf

II72F

Page 1 of 2

C701/C701A and C703/C703A

Alternators

Retrot/Upgrade Installation Instructions

   Thissymbolisusedtoindicatethepresence

   ofhazardsthatcancauseminorpersonal

   injuryorpropertydamage.

CAUTION

1. Turnoffbatteryswitchordisconnectbatteryground

cable.

2. Removealternatordrivebelt.

3. Removealloillinesbetweenalternatorandengine.

Plugoillineoutletswithproperlysizedpipeortubing

plugs.Removeoildrainhoseatexistingalternatorand

plugopening.

4. Labelwiresforidentification,thendisconnectelectri-

calconnectionsfromexistingalternator.

5. Removealternatormountingboltsandexistingalter-

natorfrommountingbracket.

6. A2-213,A2-214andA2-325regulatorsareflat-temper-

aturecompensatedandarefactory-setatlowestsetting

toaccommodate8Dbatteries.Forotherbatteries:

a. Changevoltageselectorswitchpositiononbottom

 ofregulator.SeeTable1atright.

b. Re-installregulatorondriveendhousing.Torque

 mountingscrewsto8.5Nm/75lb.in.

7. Unitsareshippedwithshaftcollar,specificwasher

andnut.Removeanddiscardshaftcollar.Install

pulleyandfurnishedwasher.Torquenutto162.7Nm/

120lb.ft.C703/C703Aunits:Useflangewasherwith

newerstylepulleyandplainwasherinenvelopewith

olderstylepulley.

8. Installalternator:

a. Carefullyplacealternatoronalternatormounting

 bracket.

    Usecautionwhenliftingalternator

    topreventpossibleminorpersonal

    injury.Usehoistalongwithalternator

    liftingringlocatedontopofthe

    alternator.

 b. Securealternatortoalternatormountingbracket.

 Mountingboltsshouldextend17.8/25.4mm

 (0.7/1.0in.)intoalternatormountingrail.Usefour

 1/2-13,grade5orhighermountingboltswith

 lockwashers(existinghardwaremaybesuitable).

 Torquemountingboltsto88Nm/65lb.ft.

Figure1–C701/C701A/C703/C703AAlternatorInstallationDetails

CAUTION

B+terminal



C701/C701A:B–terminal3/8-16bolt–

torqueto15Nm/11lb.ft.

C703/C703A:B–terminalM10bolt–

torqueto15Nm/11lb.ft.



A2-214/A2-325:D+terminal1/4-20nut–torqueto3.4Nm/30lb.in.

A2-213:D+terminalM6nut–torqueto4.5Nm/40lb.in.



A2-214/A2-325:IGNterminal#10-24nut–torqueto3.4Nm/30lb.in.

A2-213:IGNterminalM5nut–torqueto4.5Nm/40lb.in.

C701/C701A:3/4-16nut–torqueto163Nm/120lb.ft.

C703/C703A:M20x1.5mmflangenutorplainnut–

torqueto163Nm/120lb.ft.



C701/C701A:Hardenedflatwasher

C703/C703A:Bellevillewasher



C701/C701A:1/2-13bolt–torqueto30Nm/22lb.ft.

C703/C703A:M12bolt–torqueto30Nm/22lb.ft.

Flatwasher

Batteryoutput

cableterminal

Lockwasher

Insulator



Cableclamp



Alternatorliftingring

A2-214/A2-325:Pterminal1/4-20

nut–torqueto3.4Nm/30lb.in.

A2-213:PterminalM6nut–

torqueto4.5Nm/40lb.in.



*Usethissetpointtomaintainproperbatterychargelevelduring

 shorteroperatingcycles.

If an extended wiring harness is supplied for use

with alternator and regulator, see separate

instructions provided with harness.

Table1–RegulatorVoltageSelectorSwitchPosition

Position BatteryType

1 27.5V Maintenance

2 28.0V Maintenance*

3 28.5V Maintenance-Free

4 29.0V Maintenance-Free*

   Thissymbolisusedtoindicatethepresence

   ofhazardsthatcancauseseverepersonal

   injuryorsubstantialpropertydamage.

WARNING

1 2

Indice de contenidos

Pagina 1 - Alternators

II72FPage 1 of 2C701/C701A and C703/C703A AlternatorsRetrot/Upgrade Installation Instructions   Thissymbolisusedtoindicatethepresence 

Pagina 2 - Page 2 of 2

II72FPage 2 of 2C. E. Niehoff & Co. • 2021 Lee Street • Evanston, IL 60202 Tech Servi

Comentarios a estos manuales

Sin comentarios

Ce-niehoff-co C701etc/C703etc Alternator Retrofit/Upgrade Instal Manual de usuario

Busca en linea o descarga Manual de usuario para Hardware Ce-niehoff-co C701etc/C703etc Alternator Retrofit/Upgrade Instal. C.E. Niehoff & Co. C701etc/C703etc Alternator Retrofit/Upgrade Installation User Manual Manual de usuario

Indice de contenidos

Comentarios a estos manuales

Relacionado con productos y manuales para Hardware Ce-niehoff-co C701etc/C703etc Alternator Retrofit/Upgrade Instal